Analyses of Monascus pigment secretion and cellular morphology in non‐ionic surfactant micelle aqueous solution
نویسندگان
چکیده
Monascus pigments produced by Monascus spp. are widely used as natural food colourants. Extractive fermentation technology can facilitate the secretion of intracellular Monascus pigments into extracellular non-ionic surfactant micelle aqueous solution, so as to avoid the feedback inhibition and decomposition. In this study, behaviour of the trans-membrane secretion of Monascus pigments was investigated using morphological and spectroscopic analyses. Laser scanning confocal microscopy (LSCM) traced that pigment secretion occurred through rapid trans-membrane permeation in 4 min, with a simultaneous conversion in pigment characteristics. Approximately 50% of intracellular pigments (AU470 ) extracted to extracellular broth with 40 g l-1 Triton X-100, indicating the capacity for pigment extraction was limited by the saturation concentrations of surfactant. Scanning electron microscope (SEM) and transmission electron microscope (TEM) imaging showed some damage in the cell wall but an intact cell membrane with a slightly increased mycelial diameter. However, the physiological properties of the cell membrane, including integrity, fluorescence intensity and permeability, were altered. A diagram was provided to demonstrate the behaviour of Monascus pigment secretion induced by Triton X-100. This study lays a foundation for the further investigation of Monascus pigment metabolism and secretion in extractive fermentation.
منابع مشابه
Solubilization capacity of nonionic surfactant micelles exhibiting strong influence on export of intracellular pigments in Monascus fermentation
In this study, perstractive fermentation of intracellular Monascus pigments in nonionic surfactant micelle aqueous solution had been studied. The permeability of cell membrane modified by nonionic surfactant might have influence on the rate of export of intracellular pigments into its extracellular broth while nearly no effect on the final extracellular pigment concentration. However, the solub...
متن کاملInteraction and micellar behavior of aqueous mixtures of surface active ionic liquid and cationic surfactant: experimental and theoretical studies
The interaction between an ionic liquid (1-dodecyl-3-methylimidazolium bromide or IL) and cationic surfactant (dodecyltrimethylammonium bromide (DTAB)) in aqueous solution has been investigated at various mole fractions and temperature 30 ˚C using experimental and theoretical methods. The critical micelle concentration (CMC) of pure components and their binary mixtures, mixed micellar compositi...
متن کاملTracking of pigment accumulation and secretion in extractive fermentation of Monascus anka GIM 3.592
BACKGROUND Monascus pigments are promising sources for food and medicine due to their natural food-coloring functions and pharmaceutical values. The innovative technology of extractive fermentation is used to promote pigment productivity, but reports of pigment trans-membrane secretion mechanism are rare. In this study, tracking of pigment accumulation and secretion in extractive fermentation o...
متن کاملMicelle Mediated Preconcentration of Mercury in pH Controlled Mode for Trace Analysis
A micell-mediated phase separation method for preconcentration of ultra-trace quantities of mercury as a prior step to its determination by UV-Vis spectrophotometry has been developed. The method is based on Hg(II)-dithizone complex formation in alkaline aqueous solution, and extraction of this Hg(II)-dithizone secondary complex into the surfactant-rich phase of the non-ionic surfactant oct...
متن کاملAnionic/Non-ionic Surfactants in Aqueous Phase of Thin Film Composite Poly(Paraphenylene Terephthalamide) Nanofiltration Membranes
In this work, the Interfacial interfacial polymerization (IP) technique was employed using terephthaloyl chloride (TPC) and p-phenylenediamine (PPD), as reactant monomers, to prepare poly(paraphenylene terephthalamide) thin film composite (TFC) nanofiltration on polyethersulphone (PES) support layer. The effects of six different anionic and non-ionic surfactants, in the aqueous phase on the mor...
متن کامل