Removal of silicates from gibbsite-bauxite ore by using cationic reverse flotation
نویسندگان
چکیده
This paper is one of a study that implements reverse flotation methods as an alternative beneficiation on bauxite processing. aimed at decrease silica content and increase alumina in so its qualified feed Bayer Process. The experiments were carried out 1375 mL cell tank. Dodecylamine (DDA) AERO 3000C used the collector, starch depressant, Dowfroth 1012 frother. overall conducted solid to solution 25% w/w. Alumina results analyzed by XRF. XRF products show increasing decreasing content. optimum pH range using DDA collectors can be achieved 4 – 10. From results, performance better than because get higher Al2O3 content, 61.4%. collector dosage 10 gives good result 62% SiO2 29.4% with 50.44% recovery obtained 500 g/ton. ontent which conditions without addition depressant 66.8% while 23.5%. While for size fraction variation, it shows separation finer particle result. best condition this was 400 g/ton dosage, -325 mesh 79.1% 8.89%.
منابع مشابه
Removal of Lead Ions from Aqueous Solution by Sorptive-Flotation Using Limestone and Oleic Acid
A simple, rapid and economic procedure was presented to remove lead(II) from aqueous solution under the optimized conditions. It is based on the sorption of Pb2+ ions from aqueous solutions onto limestone fines (LS), which is an inexpensive and widespread over the globe, followed by flotation with oleic acid (HOL) surfactant. The different parameters (namely: solution pH, sorbent...
متن کاملRemoval of Cationic Dyes from Aqueous Solution using Organomodified Nanoclay
In this work, organomodified nanoclay has been used as the adsorbent for the removal ofbasic blue 41, cationic dye from an aqueous solution. The performance of the organomodified nanoclay was tested in a batch system under varying pH (2–12), adsorbent dosage (0.1–2 g L-1), initial dye concentration (10–60 mgL-1), and contact time (5- 100 min). The best conditions were achieved at pH of 7,...
متن کاملConcentration of bauxite fines via froth flotation (
Companhia Brasileira de Alumínio (CBA) has bauxite processing plants at Poços de Caldas and Itamarati de Minas, and a new processing plant at Miraí that has been operating since June, 2008; all of them are in the State of Minas Gerais. The plants haveunits for the crushing, scrubbing and screening operations. The screened oversize is the concentrate or washed bauxite. At Itamarati de Minas, the...
متن کاملBentazon removal from aqueous solution by reverse osmosis; optimization of effective parameters using response surface methodology
Although bentazon is widely used as an agricultural herbicide, it is harmful to humans and poses many environmental threats. This study focused on the treatment of wastewater contaminated with bentazon pesticides using membrane technology. In this regard, low-pressure reverse osmosis (RO) was employed as it has already been used in the removal of other micro-pollutants. The effects of process v...
متن کاملBeneficiation of a low-grade iron ore by combination of wet low-intensity magnetic separation and reverse flotation methods
Beneficiation of a low-grade iron ore was investigated by combination of the low-intensity magnetic separation and reverse flotation methods. The main constituents of the representative sample were 36.86% Fe, 8.1% FeO, 14.2% CaO, 13.6% SiO2, and 0.12% S based on the X-ray fluorescence, titration, and Leco analysis methods. The mineralogical studies by the X-ray diffraction, scanning electron mi...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: Nucleation and Atmospheric Aerosols
سال: 2021
ISSN: ['0094-243X', '1551-7616', '1935-0465']
DOI: https://doi.org/10.1063/5.0061567