The demand for alternate fuels used in the operation of I.C engine is met with CNSL (Cashew nut shell liquid) a by-product of cashew industry which is considered as an economically suitable for producing biodiesel. Cashew nut shell liquid is obtained from the hard cashew nut shell, cardinal a natural phenol obtained from the pyrolysis of CNSL at reduced pressure. The viscosity of the cardinal i...

The influence of KOH addition and air pretreatment on co-pyrolysis (600 °C) of a mixture of bio-oil and biomass (aspen wood) was investigated with the goal of increasing biochar yield. The bio-oil was produced as a byproduct of the pyrolysis of biomass and recycled in subsequent runs. Co-pyrolysis of the biomass with the recycled bio-oil resulted in a 16% mass increase in produced biochar. The ...

Western Research Institute is developing a new pyrolysis process called ROPE© (Recycle Oil Pyrolysis and Extraction) for recovering products from tar sands that require a minimum of upgrading to produce finished, marketable fuels or that can be used as a diluent to decrease the pour point of bitumen for transportation. The concept consists of two pyrolysis steps: (1) retorting tar sand at a low...

A combined pyrolysis and gasification process for sewage sludge was studied in this paper for the purpose of its safe disposal with energy self-balance. Three sewage sludge samples with different dry basis lower heat values (LHV(db)) were used to evaluate the constraints on this combined process. Those samples were pre-dried and then pyrolysed within the temperature range of 400-550 degrees C. ...

The objective of this study was to obtain vapor pressure and heat of vaporization values of the less volatile heavy end of the Kukersite oil shale primary pyrolysis oil and therefore to have a quantitative insight into the vaporization ability of the oil during the pyrolysis process. The shale oil was produced via rapid pyrolysis in a laboratory scale reactor and collected in a solvent filled c...

The biofuel mix in transport in the UK must be increased from currently exploited 3.33% to the EU target mix of 10% by 2020. Under the face of this huge challenge, the most viable way forward is to process infrastructure-compatible intermediate, such as bio-oil from fast pyrolysis of lignocellulosic biomass, into biofuels. New facilities may integrate multiple distributed pyrolysis units produc...

The aim of this study was to investigate the influence of reaction temperature and wheat straw moisture content on the pyrolysis product yields, in the temperature range of 475-575 °C. Samples of straw with moisture contents from 1.5 wt % to 15.0 wt % were fed to a bench scale Pyrolysis Centrifuge Reactor (PCR). The experimental results show that the changes in straw moisture content have no si...

Microwave pyrolysis of distillers dried grain with solubles (DDGS) was investigated to determine the effects of pyrolytic conditions on the yields of bio-oil, syngas, and biochar. Pyrolysis process variables included reaction temperature, time, and power input. Microwave pyrolysis of DDGS was analyzed using response surface methodology to find out the effect of process variables on the biofuel ...

Oil palm shell (OPS) is biomass with high carbon and hydrogen content, so it has the potential to produce renewable energy through thermochemical method. Pyrolysis a relatively inexpensive method that continuously converts into valuable gas, bio-oil, char products. Bio-oil used directly fuel boilers furnaces or oil. This article reviews pyrolysis process of from oil shells, discussing operating...