The coking process is considered to be a potential source of unintentionally produced persistent organic pollutants (UP-POPs). However, intensive studies on the emission of UP-POPs from the coking industry are still very scarce. Emission of polychlorinated dibenzo-p-dioxins/dibenzofurans (PCDD/Fs), dioxin-like polychlorinated biphenyls (dl-PCBs), hexachlorobenzene (HxCBz), and pentachlorobenzen...

In this study, ultraviolet (UV) and vacuum ultraviolet (VUV) photolysis were investigated for the pre-treatment and post-treatment of coking wastewater. First, 6-fold diluted raw coking wastewater was irradiated by UV and VUV. It was found that 15.9%-35.4% total organic carbon (TOC) was removed after 24 hr irradiation. The irradiated effluent could be degraded by the acclimated activated sludge...

More than 80% of ammonia (NH₃) in the steel manufacturing process wastewater is contributed from the coking wastewater, which is usually treated by biological processes. However, the NH₃ in the coking wastewater is typically too high for biological treatment due to its inhibitory concentration. Therefore, a two-stage process including a hollow fiber membrane contactor (HFMC) and a modified memb...

Introduction FCC decant oil is the primary feedstock to delayed coker to produce needle coke, a premium carbon precursor to synthetic graphite electrodes. Mesophase development during coking, determines the graphitizability of the needle coke product. Mesophase development, in turn, depends on the molecular composition of the feedstocks [1,2]. In a commercial delayed coking unit, liquid-phase c...

The effect of differential crushing on liberation characteristics has been studied for a low volatile coking coal Indian origin through washability studies. Two parameters, namely “Index Washability” (IW) and “Near Gravity Material Index” (NGMI), are used to describe the ease washability. ROM Coal is crushed four different top sizes namely, 75mm, 25mm, 13mm 6mm.On basis calculated IW it observe...

Objective(s):To investigate the effect of Eucheuma cottonii on alveolar macrophages (AM) and malondialdehyde (MDA) levels in bronchoalveolar lavage fluids (BALF) in particulate matter 10 (PM10) coal dust-exposed rats. Materials and Methods: Ten groups, including a non exposed group and groups exposed to coal dust at doses of 6.25 (CD6.25), 12.5 (CD12.5), or 25 mg/m3 (CD25) an hour daily for 6 ...

The functional response to and recovery from coal-coking waste effluent was evaluated for sediment microbial communities. Twenty estimates of microbial population density, biomass, and activity were measured five times during a 15-month period. Significant effects on microbial communities were observed in response to both wastewater contamination and diversion of the wastewater. Multivariate an...

A numerical model of a tower boiler burning low calorific value and high-alkali coal was established; based on the jet rigidity flow field in furnace, effects air velocity volume combustion NOx emissions were studied. The optimal parameters obtained by simulation are applied to typical experimental boiler. results show that when SOFA operates at about 65 m/s, is obviously increased, temperature...