Due to the abundant coal reserves in China, coal is expected to be the most important energy resource in the future. The ash deposition/slagging behavior can obviously affect the heat transfer efficiency of heat transfer tubes in boiler, and cause increasing coal consumption. In order to clarify the effect of ash deposition behavior on heat transfer characteristics of the tube in boiler, a pulv...

Glass-ceramics are polycrystalline materials of fine microstructure that are produced by the controlled crystallisation (devitrification) of a glass. Numerous silicate based wastes, such as coal combustion ash, slag from steel production, fly ash and filter dusts from waste incinerators, mud from metal hydrometallurgy, different types of sludge as well as glass cullet or mixtures of them have b...

Fly ashes and gypsum are one of the main wastes produced in coal-fired power stations which may be sent to landfills for their disposal. In this work, leaching and speciation of mercury in fly ashes and gypsum from a modern co-combustion power plant equipped with a selective catalytic reduction (SCR) unit in the Netherlands were studied. The mercury leachable contents were checked against diffe...

The removal ofxylenol orange from aqueous solution onto the coal ash was investigated at room temperature. The results show that the adsorption capacity of xylenol orange increased as the adsorption time increased and then equilibrium established after 30 min adsorption time. The results obtained revealed that the coal ash removed about 80 % of xylenol orange from the aqueous solution withi...

Municipal solid waste (MSW) incineration is a common and effective practice to reduce the volume of solid waste in urban areas. However, the byproduct of this process is a fly ash (IFA), which contains large quantities of toxic contaminants. The purpose of this research study was to analyze the chemical, physical and mechanical behaviors resulting from the gradual introduction of IFA to an alka...

L A U R A R U H L , † A V N E R V E N G O S H , * , † G A R Y S . D W Y E R , † H E I L E E N H S U K I M , ‡ A N D A M R I K A D E O N A R I N E ‡ Division of Earth and Ocean Sciences, Nicholas School of the Environment, 205 Old Chemistry Building, Box 90227, Duke University, Durham, North Carolina 27708, United States, and Civil and Environmental Engineering, 121 Hudson Hall, Box 90287, Duke ...

In this paper, effects of the operating pressure on ash formation reported in the open literature have been reviewed. In particular, the recent significant advances achieved at the Cooperative Research Centre for Coal in Sustainable Development (CCSD) in Australia are highlighted. The operating pressure significantly influences the size and the chemistry of ash generated through its effects on ...

Online coal analyzers have been in commercial use for more than two decades now, with coal producers accounting for most of the units purchased. In the past three years or so, coal-fired power plants have shown an increasing share of the analyzers bought. This article explains the most common applications of analyzers at power plants, ranging from boiler optimization to compliance with emission...

Pulverized Wyoming subbituminous coal was beneficiated by low-pH oil agglomerationat CONSOL to prepare the coal for direct liquefaction. Conventional cleaning is not veryeffective in cleaning this coal; for example, conventional oil agglomeration only givesabout 20% ash rejection. To improve ash rejection, the coal-water slurry was acidifiedto a pH of about 0.5. Oil agglomeratio...

In this study, an extraction method and environmental scanning electron microscopy (SEM) are employed to reveal the changes in the occurrence mode of fluorine in a coal-fired power plant in Inner Mongolia, China. The different occurrence states of fluorine during coal combustion and emission show that fluorine in coal mainly assumes insoluble inorganic mineral forms. The results illustrate that...