ENRICHMENT OF A HARD-ROCK GOLD ORE USING FLOTATION AND CYANIDATION
نویسندگان
چکیده مقاله:
Gold deposits are varied regarding their geological and geochemical settings. Hence,their processing methods must be best organized for achieving the desired recovery of preciousmetals. In this research, two types of hard-rock gold ores, each with specific characteristics fromKouh-zar region (south of Damghan city) were subjected to mineral processing tests at thelaboratory scale. The reference (head) samples of both veins contained on average 3.5-4.5 ppmgold. According to mineralogical investigations no observable gold particles reported even inSEM analyses except for rare over-micrometer gold particles locked in the silica matrix.Therefore, the major (invisible) gold supposed to exist in sulfides" crystal structure. Flotationapplied to recover the gold interlocked within sulfides. The highest grades achieved were 49.2ppm @ R=77.61% for Baghu samples and 57.0 ppm @ R=61.00% for Darestan samples gold inthe sulfide concentrates. In the cyanidation diagnostic tests the optimum conditions of pH,particle size, cyanide concentration and leaching time were determined for both ores. High goldrecoveries (> 95%) were achievable for Baghu samples for the pH conditions between 10.5 and11, and cyanide and hydrated lime consumptions of 0.6 and 2.5 grams per kilogram of orerespectively. As it had been expected, direct cyanidation of Darestan samples (containing up to1.5% copper), couldn"t be established as an efficient procedure (due to cyanide consumption ofabout 20 times higher than for Baghu tests to achieve similar recoveries) and the preliminarycopper removal phase was determined as a necessity for better recovery of gold.
منابع مشابه
Evaluation of the Cyanidation Leaching of Gold in a Waste Rock Ore
Samples of the waste rock obtained from Marofengin South Africa ground 60, 70 and 80% passing 75µm were leached with cyanide in bottle roll tests. The results obtained showed that the percentage gold dissolution depends more on the ore size consists than on the cyanide concentration with the highest average dissolution rates of 88.75, 94.34 and 95.90% found at 600, 500 and 500 ppm, for 60, ...
متن کاملevaluation of the cyanidation leaching of gold in a waste rock ore
samples of the waste rock obtained from marofengin south africa ground 60, 70 and 80% passing 75µm were leached with cyanide in bottle roll tests. the results obtained showed that the percentage gold dissolution depends more on the ore size consists than on the cyanide concentration with the highest average dissolution rates of 88.75, 94.34 and 95.90% found at 600, 500 and 500 ppm, for 60, 70 a...
متن کاملProcessing of Low Grade Fine Manganese Ore Using Flotation Method
Application of gravity and magnetic separation methods to upgrade low grade Manganese ores from Venaj Mine has been reported elsewhere. This paper discusses the results of flotation tests, as well as combination of flotation and magnetic method to concentrate fine particles (less than 150 microns) of manganese ore. Results obtained from various direct and reverse flotation tests, using differen...
متن کاملProcessing of Low Grade Fine Manganese Ore Using Flotation Method
Application of gravity and magnetic separation methods to upgrade low grade Manganese ores from Venaj Mine has been reported elsewhere. This paper discusses the results of flotation tests, as well as combination of flotation and magnetic method to concentrate fine particles (less than 150 microns) of manganese ore. Results obtained from various direct and reverse flotation tests, using differen...
متن کاملFroth flotation of phosphate rock
The development of froth flotation is traced from its earliest-known use through the discoveries leading to the present knowledge of the science. The factors influencing the flotation of non-sulfide and non-metallic minerals are discussed, and the machines used in commercial flotation operations are described. Experimental work on the flotation beneficiation of phosphate rock is presented as an...
متن کاملمنابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ذخیره در منابع من قبلا به منابع من ذحیره شده{@ msg_add @}
عنوان ژورنال
دوره 1 شماره 4
صفحات 9- 15
تاریخ انتشار 2004-12
با دنبال کردن یک ژورنال هنگامی که شماره جدید این ژورنال منتشر می شود به شما از طریق ایمیل اطلاع داده می شود.
کلمات کلیدی برای این مقاله ارائه نشده است
میزبانی شده توسط پلتفرم ابری doprax.com
copyright © 2015-2023