Influence of silicon on cementite precipitation in steels
نویسندگان
چکیده
The mechanism by which relatively small concentrations of silicon influence the precipitation of cementite from carbon supersaturated austenite and ferrite are investigated. It is found that one condition for the retardation of cementite is that the latter must grow under para-equilibrium conditions, i.e. the silicon must be trapped in the cementite. However, this is not a sufficient condition in that it can only be effective in retarding the transformation rate if the overall driving force for the reaction is not large. It is demonstrated that the experience that silicon retards the tempering of martensite requires the presence of lattice defects which can reduce the amount of carbon available for precipitation and the associated driving force.
منابع مشابه
High-Strength Bainitic Steels
With careful design, mixed microstructures consisting of fine plates of upper bainitic ferrite separated by thin films of stable retained austenite have exhibited impressive combinations of strength and toughness in highsilicon bainitic steels. The silicon suppresses the precipitation of brittle cementite leading to an improvement in toughness. The essential principles governing the optimisatio...
متن کاملAn Analytical Electron Microscopy Study of Paraequilibrium Cementite Precipitation in Ultra-High-Strength Steel
To support quantitative design of ultra-high-strength (UHS) secondary-hardening steels, the precipitation of cementite prior to the precipitation of the M2C phase is investigated using a model alloy. The microstructure of cementite is investigated by transmission electron microscopy (TEM) techniques. Consistent with earlier studies on tempering of Fe-C martensite, lattice imaging of cementite s...
متن کاملε-carbide in Alloy Steels: First-principles Assessment
There is now a large volume of sophisticated steels which rely on silicon as an alloying addition with the purpose of avoiding the precipitation of cementite. But there is also evidence that the silicon can enhance the formation of ε–carbide; the mechanism of this effect is not understood and the absence of appropriate thermodynamic data makes it impossible to conduct calculations. We report he...
متن کاملSubstitutional solution of silicon in cementite: A first-principles study
Cementite precipitation from austenite in steels can be suppressed by alloying with silicon. There are, however, no validated thermodynamic data to enable phase equilibria to be estimated when silicon is present in cementite. The formation energies of Fe3C, (Fe11Si 4c Fe)C4 and (Fe11Si 8d Fe)C4 have therefore been estimated using firstprinciples calculations based on the total-energy all-electr...
متن کاملThe Silicon Effect in the Tempering of Martensite in Steels
High-silicon steels have long been known to possess exceptional resistance to tempering, but the reasons for this effect were unknown. We report here a study of the third stage of tempering of these steels, in which cementite is formed. In a 0.75 wt% C 1.4 wt% Si alloy steel, tempered for 1 hour at 380°C, it is found that silicon atoms are rejected from the growing cementite into the ferrite ma...
متن کامل