A Study of Resonant State of Pressure Pulsation in a Simple Suction Pipeline of Reciprocating Compressor
نویسندگان
چکیده
Analysis and experiment show that to supercharge the suction volume of a cylinder by means of pressure pulsation is not certain to result in delay of the valve closing. To arrange a proper suction pipeline and valve cavity, we can not only get supercharge of the cylinder, but also,get economical specific power consumption, while valve working condition is good too. In this paper the methods of calculating pipe length and amplitude of pressure pulsation as well as loss qf pressure at resonant state are recommended. Experiment of verification was done on a double-acting air compressor type L 2-10/7.
منابع مشابه
Analysis of Cavity Resonance in 5 HP Hermetic Reciprocating Compressor with Elliptical Shell
Hermetic reciprocating compressor with elliptical shell radiates noise whose frequency spectrum has a peak level at about 200 Hz and about 300 Hz. The 200 Hz and 300 Hz noise is mainly radiated from the top and the side of the compressor shell, respectively. For clarifying the noise radiation mechanism, experimental and theoretical analyses were performed. A noise source simulation test was set...
متن کاملAdvanced Technologies in Reciprocating Compressor with Respect to Performance and Reliability
Reciprocating compressors are most common type of compressor and most flexible machine to handle wide capacity and condition swings. They offer a most efficient method of gas compressing. They are vital machines in various units of industrial plants. In this paper advanced technologies and latest configurations and methods regarding condition monitoring, performance, flow management, capacity c...
متن کاملDesign Of The Suction Muffler Of A Reciprocating Compressor
The suction muffler of a reciprocating compressor is used for reducing a noise produced by pressure pulsations. According to the shape, the suction muffler is classified into one-chamber type, two-chamber type, Helmholtz-resonator type, pipe-resonator type, and so on. These mufflers are used according to the characteristics of the frequency of compressor noise. In this study, four pole paramete...
متن کاملAnalysis of Enhanced Heat Exchange Caused by Pressure Pulsation in Cooler of Reciprocating Compressor
In the present paper , dynamic characteristics of the pressure pulsation and heat exchange have been analyzed in cooler of reciprocating compressor. Through the analysis of energy balance for an heat exchange element , the differential equations are established for the heat exchange element. Effect of the pressure pulsation on heat exchange has been considered in the cooler of the compressor by...
متن کاملFault Diagnosis of Reciprocating Compressor Using Pressure Pulsations
The major problems encountered in a reciprocating compressor are because of the valve failure .The other problem of leakage past the piston because of the worn out piston rings has also been placed in the reciprocating compressor. Pressure pulsations generated inside the piping of a reciprocating compressor may be taken as one of the tool for diagnosing the nature of fault inside the compressor...
متن کامل