Thermophilic anaerobic digestion to increase the net energy balance of corn grain ethanol.
نویسندگان
چکیده
U.S. production of fuel ethanol from corn grain has increased considerably over the last 10 years. Intense debate regarding the true environmental impact of the overall production process has been ongoing. The present study evaluated the utilization of thin stillage (a major byproduct of the dry-mill corn grain-to-ethanol process) in laboratory-scale thermophilic anaerobic sequencing batch reactors for conversion to methane. We found that augmentation of cobalt as a growth factor to the thermophilic anaerobic digestion process is required. After reaching sustainable operating performances, the methane potential in the reactors was 0.254 L CH4/g total chemical oxygen demand (TCOD) fed. Together with a reduction in the mass of solids that needs drying, methane generation translates to a 51% reduction of natural gas consumption at a conventional dry mill, which improves the net energy balance ratio from 1.26 to 1.70. At the design hydraulic retention time of 10 days, the digesters achieved TCOD, biodegradable COD, volatile solids, and total solids removal efficiencies of 90%, 75%, 89%, and 81%, respectively. We also found that struvite precipitation occurred in the thermophilic digesters during the course of the study, resulting in possibilities for nutrient recovery.
منابع مشابه
Anaerobic digestion of whole stillage from dry-grind corn ethanol plant under mesophilic and thermophilic conditions.
Anaerobic digestion of whole stillage from a dry-grind corn-based ethanol plant was evaluated by batch and continuous-flow digesters under thermophilic and mesophilic conditions. At whole corn stillage concentrations of 6348 to 50,786 mg total chemical oxygen demand (TCOD)/L, at standard temperature (0 °C) and pressure (1 atm), preliminary biochemical methane potential assays produced 88±8 L (4...
متن کاملInhibition of Thermophilic Anaerobic Digestion of Waste Food by Long Chain Fatty Acids and Propionate
متن کامل
Modelling the energy balance of an anaerobic digester fed with cattle manure and renewable energy crops.
Knowledge of the net energy production of anaerobic fermenters is important for reliable modelling of the efficiency of anaerobic digestion processes. By using the Anaerobic Digestion Model No. 1 (ADM1) the simulation of biogas production and composition is possible. This paper shows the application and modification of ADM1 to simulate energy production of the digestion of cattle manure and ren...
متن کاملInfluence of Processing of Barley Grain on Characteristics of Digestion, Ruminal Fermentation and Digestible Energy of Diet inLactating Cows
A digestion trial using cannulated lactating cows was conducted to evaluate the influence of barley grain processing on characteristics of ruminal fermentation and the site and extent of digestion. The experiment consisted in 4 periods and lasted 84 days. The total mixed rations contained 39.86% of grains and 42.90% of alfalfa hay and the rest of ration was composed mainly by cane molasses, fat...
متن کاملRate and extent of digestion of the ethanol-soluble and neutral detergent-insoluble fractions of corn grain.
The objectives of this study were to partition corn grain into three digestible fractions and to measure the rate of disappearance of these fractions in vitro. Seventeen corn grain samples with varied fiber concentrations were extracted with either 80% ethanol or neutral detergent to obtain estimates of the pool size and digestion kinetics of the A, B1, B2, and C fractions. The carbohydrate sol...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
عنوان ژورنال:
- Environmental science & technology
دوره 42 17 شماره
صفحات -
تاریخ انتشار 2008