Thick-film permanent magnets by membrane electrodeposition
نویسندگان
چکیده
Thick films of nearly equiatomic Co–Pt produced by electrodeposition into nanoporous membranes exhibit an isotropic magnetic phase with square hysteresis loops sMr /Ms=0.95d and coercivity of up to 1.3 T. The initial magnetization curve is characteristic of pinning-type magnets. The coercivity can be controlled by the choice of annealing temperature or alloy composition, which depends on the chemical composition of the plating bath, properties which can be exploited to produce fine-pitch pole patterns. © 2005 American Institute of Physics. fDOI: 10.1063/1.1923587g
منابع مشابه
Application of PLD-Fabricated Thick-Film Permanent Magnets
Isotropic Nd-Fe-B thick-film magnets have been prepared using a pulsed laser deposition (PLD) method with the control of laser energy density (LED) followed by post-annealing. The characteristics of the method are a high deposition rate up to several tens of microns per hour together with a reliability of magnetic properties due to the good transfer of composition from an Nd-Fe-B target to a fi...
متن کاملElectrodeposition of platinum nanoparticles on reduced graphene oxide as an efficient catalyst for oxygen reduction reaction
Reduced graphene oxide film was synthesized on a glassy carbon electrode by electro reduction of graphene oxide powders in aqueous solution. Then platinum nano particles were deposited on reduced graphene oxide film that was deposited on the glassy carbon electrode via electro reduction of platinum salt. The Physical morphology of the platinum on reduced graphene oxide film was evaluated by sca...
متن کاملPreparation of graded materials by laterally controlled template synthesis.
A novel scheme is presented for the synthesis of graded materials by electrodeposition in porous insulating templates. Lateral control of copper electrodeposition in nanoporous alumina membranes is achieved by application of a lateral potential gradient on a thin Au film evaporated on the membrane, used as the cathode. Formation of metal gradients in the membranes is shown to occur under condit...
متن کاملElectrodeposition of Photoactive Silicon Films for Low-Cost Solar Cells
Here we demonstrate progress on electrodeposition of photoactive silicon films from an environmentally friendly molten CaCl2 electrolyte, which is the first step of a new route to a practical low-cost silicon solar cell. We report electrodeposition of severalmicron thick silicon films on a graphite substrate in a bath of molten CaCl2 containing SiO2 nanoparticles. The best silicon deposits was ...
متن کاملA Quasi-Static Electromagnetic Analysis for Experiments with Strong Permanent Magnets
An electromagnetic analysis is presented for experiments with strong permanent disc magnets. The analysis is based on the well known experiment that demonstrates the effect of circulating eddy currents by dropping a strong magnet through a vertically placed metal cylinder and observing how the magnet is slowly falling through the cylinder with a constant velocity. This experiment is quite spect...
متن کامل