An Economic Evaluation of Automated Fault Detection and Diagnosis for Rooftop Air Conditioners
نویسندگان
چکیده
In contrast to critical systems, one of the primary consequences of faults in HVAC systems is economic rather than safety-related. Therefore, FDD systems applied to HVAC systems must be assessed based upon economic considerations. However, existing research in this application has mainly focused on technique development and validation. This paper addresses the economics of FDD application to HVAC systems. Two major aspects of savings associated with FDD application to rooftop air conditioning units (RTU) are investigated qualitatively and quantitatively: service and operating cost savings. Automated FDD reduces service costs due to reduced preventive maintenance inspections, fault prevention, lower cost fault detection and diagnosis (FDD), better scheduling of multiple service activities, and better scheduling of service to low season. Operating cost savings consist of utility cost and equipment life savings. A methodology was presented for evaluating the cost savings for application of automated FDD to RTUs. Application of the methodology to a number of sites in California sites showed that $108/ton-year, around 70% of the original service costs, could be eliminated, and the operating cost savings range from $20 to $180/ton-year, which depends on the location and application. The savings are significant and payback period for an FDD technique presented by Li and Braun (2004) that relies on low-cost sensors is less than one year.
منابع مشابه
Automated Fault Detection & Diagnostics for Rooftop Packaged Air Conditioners
Maintenance for rooftop packaged air conditioners (RTUs) is a rare preventative practice. Generally, service calls are limited to emergency response for major system failures that impact occupant comfort. Even in the case of equipment maintained under service contracts, technicians will only detect severe and obvious faults since their procedures typically only involve routine qualitative asses...
متن کاملApplication of Automated Fault Detection and Diagnostics For Rooftop Air Conditioners in California
The primary goal of the research described in this paper was to apply a decoupling-based fault detection and diagnosis (FDD) technique and economic assessment method to light commercial cooling and heating equipment in California. The paper describes the decouplingbased FDD methodology and the economic assessment method. The methods have been applied to a number of field sites. Detailed results...
متن کاملFault Detection And Diagnosis For Air Conditioners And Heat Pumps Based On Virtual Sensors
Kim, Woohyun. Ph.D., Purdue University, December 2013. Fault Detection and Diagnosis for Air Conditioners and Heat Pumps based on Virtual Sensors. Major Professor: James E. Braun, School of Mechanical Engineering. The primary goal of this research is to develop and demonstrate an integrated, on-line performance monitoring and diagnostic system with low cost sensors for air conditioning and heat...
متن کاملDiagnosis of Different Types of Air-Gap Eccentricity Fault in Switched Reluctance Motors Using Transient Finite Element Method
This paper presents a method for diagnosis of eccentricity fault in a switched-reluctance motor (SRM) during offline and standstill modes. In this method, the fault signature is differential induced voltage (DIV) achieved by injecting diagnostic pulses to the motor windings. It will be demonstrated by means of results that there is a correlation between differential induced voltage and eccentri...
متن کامل