Rapid fabrication of highly b-oriented zeolite MFI thin films using ammonium salts as crystallization-mediating agents.
نویسندگان
چکیده
A new route to the synthesis of highly b-oriented zeolite MFI films is demonstrated for the first time using ammonium salts as crystallization-mediating agents in secondary growth. The ammonium salts tailor the crystallization process and silicate-NH4(+) interactions dominate over TPA-NH4(+) interactions so that nucleation was effectively suppressed during secondary growth.
منابع مشابه
2D Zeolite Coatings: Langmuir-Schaefer Deposition of 3 nm Thick MFI Zeolite Nanosheets.
Stable suspensions of zeolite nanosheets (3 nm thick MFI layers) were prepared in ethanol following acid treatment, which partially removed the associated organic structure-directing agent. Nanosheets from these suspensions could then be dispersed at the air-water interface and transferred to silicon wafers using Langmuir-Schaefer deposition. Using layer-by-layer deposition, control on coating ...
متن کاملFabrication, characterization and investigation of gas sensing properties of MoO3 thin films
In this research, molybdenum oxide (α-MoO3) thin films were coated on glass substrates using spray pyrolysis technique. 0.05 M ammonium heptamolybdate tetrahydrate was used as precursor and deionized water as solvent. The effects of carrier gas pressure, during the spraying of the solution, on the structural, optical, morphological and gas sensing properties of thin films were studied. X-ray di...
متن کاملTEM investigation of formation mechanism of monocrystal-thick b-oriented pure silica zeolite MFI film.
The first direct transmission electron microscopic (TEM) observation has been carried out on the continuous monocrystal-thick b-oriented pure silica zeolite MFI films produced by in situ crystallization. The self-supporting film samples for TEM study were fabricated by dissolving the steel substrate with acid. This TEM study is free of those artifacts that are typically associated with TEM samp...
متن کاملHighly Oriented Growth of Catalytically Active Zeolite ZSM‐5 Films with a Broad Range of Si/Al Ratios
Highly b-oriented zeolite ZSM-5 films are critical for applications in catalysis and separations and may serve as models to study diffusion and catalytic properties in single zeolite channels. However, the introduction of catalytically active Al3+ usually disrupts the orientation of zeolite films. Herein, using structure-directing agents with hydroxy groups, we demonstrate a new method to prepa...
متن کاملReactive atmospheric pressure plasma for highly efficient removal of structure-directing agents from zeolite thin films.
We present a novel approach to remove the structure-directing agent (SDA) from as-synthesized zeolites using an atmospheric pressure plasma jet (APPJ). This reduces the time required to less than 60 seconds as compared to the existing thermal calcination, whose durations range from hours to days. The highly reactive plasma also results in a pronounced Q(3)-to-Q(4) transformation in the pure-sil...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
برای دانلود متن کامل این مقاله و بیش از 32 میلیون مقاله دیگر ابتدا ثبت نام کنید
ثبت ناماگر عضو سایت هستید لطفا وارد حساب کاربری خود شوید
ورودعنوان ژورنال:
- Chemical communications
دوره 51 55 شماره
صفحات -
تاریخ انتشار 2015