Elastoplastic contact of rough surfaces: a line contact model for boundary regime of lubrication
نویسندگان
چکیده
This paper introduces an improved friction model accounting for elastoplastic behavior of interacting asperities along contiguous rough surfaces for a line contact solution. It is based on Greenwood and Tripp’s original boundary friction model and specifically tailored for a boundary regime of lubrication. The numerical solution of Reynolds’ equation is achieved by implementing Elrod’s cavitation algorithm for a one dimensional line contact. The transience in the numerical solution is retained by accounting for the squeeze film term in Reynolds’ equation under fixed loading conditions and varying sliding motion. A sliding bearing rig is used to measure friction and compare the results with the prediction made using the approach highlighted above. The numerical/experimental results show good agreement.
منابع مشابه
Identification of Local Lubrication Regimes on Textured Surfaces by 3d Roughness Curvature Radius
This paper proposes a new method of 3D roughness peaks curvature radius calculation and its application to tribological contact analysis as a characteristic signature of tribological contact. This method is introduced through the classical approach of calculation of radius of asperity in 2D. Actually, the proposed approach provides a generalization of Nowicki's method [1], depending on horizont...
متن کاملTheory of viscoelastic lubrication
We study the lubricated (wet) contact mechanics of a smooth hard cylinder sliding on a randomly rough nominally flat surface of a linear viscoelastic solid. We calculate the rolling and sliding friction, and study the transition from the boundary lubrication to the elasto-hydrodynamic lubrication regime. For the viscoelastic contact the minimum (average) separation does not monotonically increa...
متن کاملModeling and Simulation of Spherical and Cylindrical Contact Theories for Using in the Biological Nanoparticles Manipulation
The low Young's modulus of biological particles results in their large deformation against the AFM probe forces; therefore, it is necessary to study the contact mechanics of bioparticles in order to predict their mechanical behaviors. This paper specifically deals with the contact mechanics of DNA nanoparticles with spherical and cylindrical shapes during manipulation. In previous studies, ...
متن کاملWetting of Doubly Periodic Rough Surfaces in Wenzel’s Regime
In this work we present preliminary results from our numerical study of the shapes of a liquid meniscus in contact with doubly sinusoidal rough surfaces in Wenzel’s wetting regime. Using the full capillary model we obtain the advancing and the receding equilibrium meniscus shapes for a broad interval of surface roughness factors. The contact angle hysteresis is obtained when the three-phase con...
متن کاملRole of Surface Texture on Friction and Wear under Boundary Lubricated Conditions
Ensuring effective lubrication between sliding surfaces is one of the challenges in the field of tribology. In addition to the conventional parameters like speed, load, contact geometry and material parameters, the surface texture also influences the coefficient of friction. In the present investigation, the effect of surface texture on coefficient of friction under boundary lubricated conditio...
متن کامل