Biodiesel Production from Acidified Oils via Supercritical Methanol
نویسندگان
چکیده
In biodiesel production, the vegetable oil used as raw material for transesterification should be free of water and free fatty acids (FFAs), which may consume catalyst and reduce catalyst efficiency. In this work biodiesel was prepared from acidified oils (AO) through a supercritical methanol route, in which the esterification of FFAs and transesterification of glyceride with methanol occurred simultaneously. The effects of the mass ratio of methanol to AO, the operation temperature as well as the water content on the FFAs conversion and glycerol yield were investigated. The results indicated that the FFAs conversion for esterification under the condition of 1:1 methanol/oil ratio, 310 °C and 15 min reaction time reached 98.7%, and the glycerol yield for transesterification under 0.25:1 methanol/oil ratio, 290 °C and 20 min reaction time reached 63.5% respectively.
منابع مشابه
Biodiesel production from vegetable oils by supercritical methanol
Transesterification of vegetable oils in supercritical methanol are carried out without using any catalyst. Methyl esters of vegetable oils or biodiesels have several outstanding advantages among other new-renewable and clean engine fuel alternatives and can be used in any diesel engine without modification. The most important variables affecting the methyl ester yield during the transesterific...
متن کاملNon-catalytic biodiesel fuel production with supercritical methanol technologies
Study presents that supercritical methanol has the ability to convert oils/fats consisting of triglycerides and free fatty acids (FFAs) into fatty acid methyl esters through transesterification and methyl esterification, respectively, without any catalyst. This one-step method (Saka process) is simpler process realizing shorter reaction time and higher yield of methyl esters than those of the c...
متن کاملIntegrated lipase production and in situ biodiesel synthesis in a recombinant Pichia pastoris yeast: an efficient dual biocatalytic system composed of cell free enzymes and whole cell catalysts
BACKGROUND Lipase-catalyzed biotransformation of acylglycerides or fatty acids into biodiesel via immobilized enzymes or whole cell catalysts has been considered as one of the most promising methods to produce renewable and environmentally friendly alternative liquid fuels, thus being extensively studied so far. In all previously pursued approaches, however, lipase enzymes are prepared in an in...
متن کاملTitle Two-step supercritical dimethyl carbonate method for biodiesel production from Jatropha curcas
This study reports on a novel two-step process for biodiesel production consisting of hydrolysis of oils in sub-critical water and subsequent supercritical dimethyl carbonate esterification. This process found to occur optimally at the subcritical water treatment (270°C/27MPa) for 25 min followed by a subsequent supercritical dimethyl carbonate treatment (300°C/9MPa) for 15 min to achieve a com...
متن کاملSupercritical Methanol Extraction and Transesterification of Jatropha Curcas L. Seeds for the Production of Biodiesel – Process Parameters Study
In this work, optimization of supercritical methanol extraction and transesterification for the production of biodiesel was investigated using Jatropha curcas L. seeds. Several important process parameters including heat pre-treatment (45°C-105°C for 12 and 24 hours), particle size (0.5 mm-2.0 mm) and temperature (200°C-300°C) were being studied by varying one factor at a time. The experiment w...
متن کامل