A Novel Ti-based Non-metallocene Catalyst System for Ethylene Polymerization
نویسندگان
چکیده
A novel non-metallocene titanium complex was synthesized, and used as the catalyst for ethylene polymerization. It results in an acceptable activity, affording the polyethylene with ultra high molecular weights, and relative broad molecular weight distributions. Moreover, the molecular weight almost doesn’t change with the change of Al/Ti ratio.
منابع مشابه
Group (IV) Metallocene Complexes with Bulky ω-aryloxyalkyl-Substituted Indenyl Ligands as Catalyst Precursors for Homogeneous Ethylene Polymerization
A series of seven new complexes of zirconium and hafnium with bulky ω-aryloxyalkyl substituted indenyl ligands were synthesized and characterized by NMR spectroscopy and elemental analysis. These complexes were activated with methylaluminoxane and tested for homogeneous ethylene polymerization. The zirconium catalysts showed higher activities than their hafnium an...
متن کاملEffects of Temperature and Cocatalyst Concentration on the Number of Active Sites in a TiCl4/Mg(OEt)2 Catalyst for Ethylene Polymerization
The slurry polymerization of ethylene was studied by employing a (TiCl4/Mg(OEt)2/TEA) catalyst system in hexane. The effects of triethylaluminum concentration and temperature on polymer yield and polymer viscosity average molecular weight, Mv, were investigated. The maximum polymer yield was obtained at an Al/Ti molar ratio of 124. The highest yield and Mv were achieved at 60 °C. The concentrat...
متن کاملImido-modified SiO2-supported Ti/Mg Ziegler-Natta catalysts for ethylene polymerization and ethylene/1-hexene copolymerization
A novel imido-modified SiO2-supported Ti/Mg Ziegler-Natta catalyst for ethylene and ethylene/1-hexene polymerization is investigated. The catalyst is prepared by modification of (SiO2/MgO/MgCl2)TiClx Ziegler-Natta catalysts via supporting vanadium species followed by reaction with p-tolyl isocyanate as imido agents, to get the merits from both the SiO2-supported imido vanadium catalyst and the ...
متن کاملIN SITU SILICA SUPPORTED METALLOCENE CATALYSTS FOR ETHYLENE POLYMERIZATION
Bis(2-R-ind)ZrCl2 (R: H or phenyl) was supported on different types of silica by in situ impregnation method and used for ethylene polymerization. In this method, the step of catalyst loading on support was eliminated and common alkyl aluminum (triisobutylaluminum, TiBA) cocatalyst was used instead of expensive methyl aluminiumoxane (MAO) cocatalyst in the polymerization. The effect of surface ...
متن کاملConstrained Geometry Organotitanium Catalysts Supported on Nanosized Silica for Ethylene (co)Polymerization.
Supported olefin polymerization catalysts can prevent reactor-fouling problems and produce uniform polymer particles. Constrained geometry complexes (CGCs) have less sterically hindered active sites than bis-cyclopentadienyl metallocene catalysts. In the literature, micrometer-sized silica particles were used for supporting CGC catalysts, which might have strong mass transfer limitations. This ...
متن کامل