Electron spin resonance detection of radiosterilization of pharmaceuticals: application to four nitrofurans.

The detection and dosimetry of radiosterilization of pharmaceuticals is a growing concern to numerous government regulatory agencies worldwide. In the absence of suitable detection methods, attention was focused on electron spin resonance (ESR) spectrometry. This paper reports experimental data on ESR dosimetry of irradiated nitrofurans (nitrofurantoin, nifuroxazide, nifurzide and nifurtoinol). Whereas the ESR spectrum of a non-irradiated sample shows no signal, a signal, that is dependent on the irradiation dose is observed with irradiated samples. The number of free radicals was calculated by comparing the second integral from radiosterilized samples and a Bruker strong pitch reference; the values were in the range 1.1 x 10(18)-1.5 x 10(19) radicals mol-1 (G = 0.003-0.03). In addition to qualitative detection, ESR spectrometry can be used for dose determination. When a bi-exponential function is applied to the variation of the peak-to-peak amplitude versus dose, the function correlates well with the data. However, an exponential function, easier to use than a bi-exponential function, will probably be sufficient for dose determination by retrospective dosimetry. Decay of radicals upon storage was modelled using a bi-exponential function. From this, the time limit from the irradiation (25 kGy) for identification of irradiated nitrofurans by ESR can be evaluated. With regard to the commercial aspects of drugs, radicals should be detected up to 2 years after irradiation. The kinetic decrease makes discrimination between irradiated and non-irradiated nitrofurans possible even after storage for up to 2 years, except for nifurtoinol.