High current density electrodeposition of silver from silver-containing liquid metal salts with pyridine-N-oxide ligands.

New cationic silver-containing ionic liquids were synthesized and used as non-aqueous electrolytes for the electrodeposition of silver layers. In the liquid state of these ionic liquids, a silver (i) cation is coordinated by pyridine-N-oxide (py-O) ligands in a 1 : 3 metal-to-ligand ratio, although in some cases a different stoichiometry of the silver center crystallized out. As anions, bis(trifluoromethanesulfonyl)imide (Tf2N), trifluoromethanesulfonate (OTf), methanesulfonate (OMs) and nitrate were used, yielding compounds with the formulae [Ag(py-O)3][Tf2N], [Ag(py-O)3][OTf], [Ag(py-O)3][OMs] and [Ag(py-O)3][NO3], respectively. The compounds were characterized by CHN analysis, FTIR, NMR, DSC, TGA and the electrodeposition of silver was investigated by cyclic voltammetry, linear potential scans, scanning electron microscopy (SEM) and energy-dispersive X-ray spectrometry (EDX). With the exception of [Ag(py-O)3][Tf2N], which melts at 108 °C, all the silver(i) compounds have a melting point below 80 °C and were tested as electrolytes for silver electrodeposition. Interestingly, very high current densities were observed at a potential of -0.5 V vs. Ag/Ag(+) for the compounds with fluorine-free anions, i.e. [Ag(py-O)3][NO3] (current density of -10 A dm(-2)) and [Ag(py-O)3][OMs] (-6.5 A dm(-2)). The maximum current density of the compound with the fluorinated anion trifluoromethanesulfonate, [Ag(py-O)3][OTf], was much lower: -2.5 A dm(-2) at -0.5 V vs. Ag/Ag(+). Addition of an excess of ligand to [Ag(py-O)3][OTf] resulted in the formation of the room-temperature ionic liquid [Ag(py-O)6][OTf]. A current density of -5 A dm(-2) was observed at -0.5 V vs. Ag/Ag(+) for this low viscous silver salt. The crystal structures of several silver complexes could be determined by X-ray diffraction, and it was found that several of them had a stoichiometry different from the 1 : 3 metal-to-ligand ratio used in their synthesis. This indicates that the compounds form crystals with a composition different from that of the molten state. The electrochemical properties were measured in the liquid state, where the metal-to-ligand ratio was 1 : 3. Single crystal X-ray diffraction measurements showed that silver(i) is six coordinate in [Ag(py-O)3][Tf2N] and [Ag(py-O)3][OTf], while it is five coordinate in the other complexes. In [Ag3(py-O)8][OTf]3, there are two different coordination environments for silver ions: six coordinate central silver ions and five coordinate for the outer silver ions. In some of the silver(i) complexes, silver-silver interactions were observed in the solid state.