Water Scrubber and Zeolite Catalyst for Clean Syngas Production on Biomass Gasification of Bagasse in a Downdraft System
نویسندگان
چکیده
Biomass gasification is one solution that can overcome Indonesia's energy crisis. Indonesia an agricultural country has a lot of sources biomass. This work was focused on clean syngas production with purifying process through water scrubber and zeolite catalyst as filter. The produced from bagasse solid waste sugar factory. weight feedstock studied 1000 g, 1500 2000 2500 3000 g. influence burning time composition were also production. experiment result showed the related to amount bagasse; higher bagasse, longer time. investigated, it found CO, CH4, H2 percentages 9.294%, 1.348%, 2.773%, respectively. affect cleanness syngas.
منابع مشابه
Thermodynamic Analysis of Supercritical Water Gasification of Microalgae Biomass for Hydrogen and Syngas Production
Supercritical water gasification (SCWG) is an alternative thermochemical technology for the conversion of wet biomass in a high heat value product gases, such as syngas and hydrogen. Algal biomass has been suggested as one promising option to produce biomass for use as fuels and chemical feedstocks with high area-specific yields. In this study, the thermodynamic analysis of SCWG of microalgae b...
متن کاملSulfur Tolerant Magnesium Nickel Silicate Catalyst for Reforming of Biomass Gasification Products to Syngas
Magnesium nickel silicate (MNS) has been investigated as a catalyst to convert tars and light hydrocarbons to syngas (CO and H2) by steam reforming and CO2 reforming in the presence of H2S for biomass gasification process at NexTech Materials. It was observed that complete CH4 conversion could be achieved on MNS catalyst granules at 800–900 °C and a space velocity of 24,000 mL/g/h in a simulate...
متن کاملSteam Reforming and Gasification of Pyrolysis Oil Reactor and Process Development for Syngas Production from Biomass
Gasification of pyrolysis oil was studied in a fluidized bed over a wide temperature range (523-914 °C) with and without the use of nickel-based catalysts. Noncatalytically, a typical fuel gas was produced. Both a special designed fluid bed catalyst and a crushed commercial fixed bed catalyst showed an initial activity for syngas (H2 and CO) production at T >700 °C. However, these catalysts los...
متن کاملHydrogen rich gas production via nano-catalytic gasification of bagasse in supercritical water
Ru/Al2O3 nano-catalysts were prepared with impregnation and microemulsion techniques. The supercritical water gasification reaction was performed at 400oC and 5-60 min. Within the tested operation conditions, the reaction residence time of 15 min was the optimum to maximize the H2 yield. It was observed that using microemulsion technique increases the total gas yield significantly. Using microe...
متن کاملBiomass Syngas Production Technology by Gasification for Liquid Fuel and Other Chemicals
*1 Chief Engineer, Power Systems Plant Engineering & Construction Division *2 Deputy Chief Engineer,Boiler Engineering Department, Power Systems *3 Engineering Manager, Sustainability Energy & Environment Strategic Planning Department *4 Research Manager, Yokohama Research & Development Center, Technology & Innovation Headquarters *5 Nagasaki Research & Development Center, Technology & Innovati...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: Jurnal Bahan Alam Terbarukan
سال: 2022
ISSN: ['2407-2370', '2303-0623']
DOI: https://doi.org/10.15294/jbat.v11i2.39674