Steam gasification of biomass – Typical gas quality and operational strategies derived from industrial-scale plants

Design, Optimization and Energetic Efficiency of Producing Hydrogen-Rich Gas from Biomass Steam Gasification

In this article, the conceptual design of biomass steam gasification (BSG) processes using raw oil palm (ROP) and torrefied oil palm (TOP) are examined in an Aspen Plus simulator. Through thermodynamic analysis, it is verified that the BSG process with torrefied feedstock can effectively enhance the hydrogen yield. When the heat recovery design is added into the BSG process, the system energeti...

CO2 Enhanced Steam Gasification of Biomass Fuels

The current study involves an experimental investigation of the decomposition of various biomass feedstocks and their conversion to gaseous fuels such as hydrogen. The steam gasification process resulted in higher levels of H2 and CO for various CO2 input ratios. With increasing rates of CO2 introduced into the feed stream, enhanced char conversion and increased CO levels were observed. While C...

Hydrogen-Rich Gas Production from Steam Gasification of Biomass using CaO and a Fe-Cr Water-Gas Shift Catalyst

The technical feasibility of using calcium oxide (CaO) as a sorbent for CO2 and Fe-Cr as a catalyst for the water-gas shift (WGS) reaction using syngas for the steam gasification of biomass was investigated. The effects of temperature, steam to biomass mass ratio, CaO to biomass molar ratio, and Fe-Cr WGS catalyst on gas composition were studied. Within a temperature range of 250 C to 550 C, ...

Steam Turbines for Biomass Plants

Steam-air fluidized bed gasification of distillers grains: Effects of steam to biomass ratio, equivalence ratio and gasification temperature.

In this study, thermochemical biomass gasification was performed on a bench-scale fluidized-bed gasifier with steam and air as fluidizing and oxidizing agents. Distillers grains, a non-fermentable byproduct of ethanol production, were used as the biomass feedstock for the gasification. The goal was to investigate the effects of furnace temperature, steam to biomass ratio and equivalence ratio o...