Rapid Reduction of Fine Iron Ore Transported with CH<SUB>4</SUB> Gas
نویسندگان
چکیده
منابع مشابه
Carbon Monoxide Reduction of Iron Ore
C ERTAIN attention is paid today to the weaknesses of the classical blast furnace process, and interest is continuously increasing in methods for direct reduction without melting. Several different methods have been developed or suggested in the past, but so far only a few have been adopted for practical use. Another tendency in the iron industry of today is the change-over to concentrates, wit...
متن کاملModeling of counter current moving bed gas-solid reactor used in direct reduction of iron ore
In this work, the shaft furnace reactor of the MIDREX® process is simulated. This is a counter current gas-solid reactor, which transforms iron ore pellets into sponge iron. Simultaneous mass and energy balance along the reactor leads to a set of ordinary differential equation with two points boundary conditions. The iron ore reduction kinetics was modelated with the unreacted shrinking core mo...
متن کاملMicrowaves Applied to Carbothermic Reduction of Iron Ore Pellets
Results of reducibility tests of reduction conducted on iron ore pellets with carbon are presented in this work. Work done is centered on reduction kinetics using carbon as reducing agent with conventional heat supply (heat transfer process) compared with reduction kinetics where heat is supplied by microwaves to the whole volume. Ore used in this work is called "Alzada" which has reducibility ...
متن کاملenvironmental effects of gol-e-gohar iron ore mine on groundwater of the area
gol-e-gohar iron ore mine of sirjan in southern part of iran is a large open pit that operates below the groundwater table and during mining operation, dewatering is required to prevent operation processes from flooding. current operation is going on by digging wells in or out of the pit and pumping to prevent flooding. as a result of the former dewatering operation a vast deep cone of depressi...
The Layered Reduction of Hematite (Iron Oxide) Ore by Non-Coking Coal: The Effect of Calcium Carbonate on Reduction
Due to the abundance of the non-coking coal and limitations as well as the high costs of the natural gas, the present study examined the direct reduction of hematite (iron oxide) ore in the temperature range of 800-1000 °C by the non-coking coal volatiles. Approximately, 74.9% of the total amounts of volatiles and gases exit the coal up to 800°C. The onset temperature to exit volatiles from the...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: Tetsu-to-Hagane
سال: 2005
ISSN: 0021-1575,1883-2954
DOI: 10.2355/tetsutohagane1955.91.6_521