Fluidized Bed Reduction of Iron Ore Fines by Coal Fines.
نویسندگان
چکیده
منابع مشابه
X-ray tomography of a fluidized bed Effect of pressure and fines on bubbles in a fluidized bed
Using a fast X-ray tomography setup measurements have been done on a 25 cm diameter f luidized bed of Geldart B pow^der and a 24 cm bed of Geldart A powder. The average bubble sizes have been determined over a measurement period of 60 seconds. The resolution of this setup is about 4.5 m m per pixel at a rate of 250 reconstructions per second. I t is possible to detect bubbles as small as 2.5 cm...
متن کاملHydrodynamic Characteristics of Dry Beneficiation of Iron Ore and Coal in a Fast Fluidized Bed
Iron ore and coal are the two major important raw materials being used in Iron making industries. Usually ore fines containing around 5% Alumina are rejected due to higher proportion of alumina. Therefore, a technology or process which may reduce the alumina content by 2% by beneficiation process will be highly attractive . In addition fine coals with ash content is used nearly 12% is directly ...
متن کاملPelletisation Behavior of Fluxed Iron Ore Pellets of Varying Basicities Made with Waste Fines
The present study deals with the utilization of fines generated from comminution process (crushing, grinding and screening) of the Run of Mines into value added products i.e. fluxed iron ore pellets. The study comprises to understand the physical and mechanical behavior of five distinguished chemical compositions of green and dried iron ore pellets with respect to a typical Mini Blast furnace (...
متن کاملDewatering of coal fines using a super absorbent polymer
403 The Journal of The South African Institute of Mining and Metallurgy JULY/AUGUST 2003 Introduction Coal preparation is used to upgrade run-ofmine coal before it is utilized by the end-user, primarily electric utility power plants. According to Fonseca1, the coal preparation process reduces the amount of noncombustible mineral impurities, acid-rain precursor sulphur-bearing minerals and hazar...
متن کاملThe Layered Reduction of Hematite (Iron Oxide) Ore by Non-Coking Coal: The Effect of Calcium Carbonate on Reduction
Due to the abundance of the non-coking coal and limitations as well as the high costs of the natural gas, the present study examined the direct reduction of hematite (iron oxide) ore in the temperature range of 800-1000 °C by the non-coking coal volatiles. Approximately, 74.9% of the total amounts of volatiles and gases exit the coal up to 800°C. The onset temperature to exit volatiles from the...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: ISIJ International
سال: 1991
ISSN: 0915-1559
DOI: 10.2355/isijinternational.31.1279